HAllo liebe gemeinde
ich habe Bei meinem 1,9tdi BJ 2004
die Lenkung von Generation I auf Generation II umgerüstet
Hab die komplette Lenkung samt steuergerät Leitung und Lenkwinkelsensor getauscht
Die Lenkunterstützung funktioniert und die Werte werden im Vag-Com angezeigt
Leider kann ich den Lanksensor nicht programieren und
habe ne ganze menge an fehlern +leuchtende Kontrolllampen
Chassis Type: 1K0
Scan: 01 03 08 09 15 16 17 19 25 42 44 46 52 56 7D
VIN: WVWZZZ1KZ4P001835 Mileage: 54000km/33554miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Not registered 0011
7D-Aux. Heat -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKC.lbl
Part No SW: 03G 906 016 B HW: 028 101 147 8
Component: R4 1,9L EDC 0000SG 5645
Revision: 12345678 Serial number: VWZ7Z0C8153482
Coding: 0000071
Shop #: WSC 78026 150 51231
1 Fault Found:
19559 - Motor for Intake Manifold Flap (V157): Malfunction
P3103 - 000 - -
Freeze Frame:
RPM: 882 /min
Torque: 34.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.36 V
Bin. Bits: 11000100
Torque: 148.0 Nm
Torque: 0.0 Nm
Readiness: 1 1 1 1 1
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0103
Coding: 0021122
Shop #: WSC 00028 028 00001
1 Fault Found:
00778 - Steering Angle Sensor (G85)
014 - Defective
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-820-047.lbl
Part No: 1K0 820 047 CR
Component: Climatic PQ35 081 0404
Shop #: WSC 00000 000 00000
1 Fault Found:
00898 - Control Circuit A/C compressor
010 - Open or Short to Plus
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 3C0-937-049-30-H.lbl
Part No SW: 3C8 937 049 F HW: 3C8 937 049 F
Component: Bordnetz-SG H54 2602
Revision: 00H54000 Serial number: 00000009560858
Coding: 00890F060004180000140000140000000000FF0700000000000000000000
Shop #: WSC 20921 146 95151
Part No: 1K1 955 119 A
Component: Wischer VW350 011 0301
Coding: 00065493
Shop #: WSC 20921
3 Faults Found:
02394 - Parking Light Left Front (M1)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 62
Mileage: 54001 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.60 V
ON
ON
OFF
OFF
OFF
00834 - Signal for Activation of Heated Rear Window
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 62
Mileage: 54001 km
Time Indication: 0
Freeze Frame:
OFF
Voltage: 12.75 V
OFF
ON
OFF
OFF
OFF
01800 - Light Switch (E1)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 66
Mileage: 54001 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.10 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1K0 920 850 F
Component: KOMBIINSTRUMENT VDD 1218
Coding: 0001101
Shop #: WSC 00028 028 00001
1 Fault Found:
00003 - Control Module
014 - Defective
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 C HW: 1K0 907 951
Component: Gateway H08 0080
Revision: 08 Serial number: 2100103712786F
Coding: 3D0F0B00070000
Shop #: WSC 78026 150 86558
1 Fault Found:
01044 - Control Module Incorrectly Coded
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 1
Fault Frequency: 3
Reset counter: 62
Mileage: 54001 km
Time Indication: 0
Date: 2000.00.00
Time: 00:00:48
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x.lbl
Part No: 1K0 909 144 H
Component: EPS_ZFLS Kl. 70 2901
Revision: 00H15000
Shop #: WSC 01324 785 00200
4 Faults Found:
16353 - Control Module - Internal Malfunction
014 - Defective
Freeze Frame:
Fault Status: 01101110
Fault Priority: 6
Fault Frequency: 1
Reset counter: 187
Mileage: 0 km
Time Indication: 0
Freeze Frame:
Battery Volts: 0.0 V
PD
Temperature: -70.0°C
Error Code: 0
Torque: 0.0 Nm
Torque: 0.000 Nm
RPM: 0 /min
16355 - Control Module - Watchdog Timer
014 - Defective - Intermittent
Freeze Frame:
Fault Status: 00101110
Fault Priority: 6
Fault Frequency: 1
Mileage: 0 km
Time Indication: 0
Freeze Frame:
Voltage: 0.00 V
PD
Temperature: -70.0°C
Count: 0
Count: 0
Count: 0
Count: 0
00778 - Steering Angle Sensor (G85)
008 - Implausible Signal - MIL ON
Freeze Frame:
Fault Status: 11101000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 62
Mileage: 54001 km
Time Indication: 0
Date: 2000.00.00
Time: 00:02:41
Freeze Frame:
Battery Volts: 14.8 V
DU
Temperature: 21.0°C
Count: 5
Steering Angle: -11.94°
Count: 0
SteerAng lnit
01316 - ABS Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 62
Mileage: 54001 km
Time Indication: 0
Date: 2000.00.00
Time: 00:02:41
Freeze Frame:
Voltage: 14.50 V
DU
Temperature: 21.0°C
RPM: 902 /min
Speed: 50.0 km/h
Speed: 50.0 km/h
Count: 0
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN1.lbl
Part No: 1K0 959 702 E
Component: Tuersteuergeraet 09 0103
Coding: 0000064
Shop #: WSC 00028 028 00001
1 Fault Found:
00121 - Outside Warning Light/Door exit Light Passenger Side
012 - Electrical Fault in Circuit
End ---------------------------------------------------------------------